移动混凝土搅拌机动力强劲_行业资讯_自动混凝土搅拌机知识_自动混凝土搅拌机_自动混凝土搅拌车厂家

站内搜索

自动混凝土搅拌机知识

公司新闻行业资讯

热点

降低自动搅拌车零件磨损需注意的问题！

2021-02-06

混凝土搅拌车油箱气孔的作用你知道吗？

2021-03-03

什么是影响自动搅拌机寿命的因素？

2020-12-07

自动混凝土搅拌车运行的几条秘籍

2021-11-13

关于山汽

联系人：刘老师

电话：400-879-1999

公司：山东山汽工程机械（集团）有限公司

地址：山东省莱州市206国道与308省道交叉口东南50米

移动混凝土搅拌机动力强劲

所属分类：行业资讯发布时间：2022-08-09 来源：http://www.sqjituan.cn/ 浏览量：0

轮式移动混凝土搅拌机动力强劲混凝土搅拌车装料前，应先排净拌筒内残存的积水和杂物，在运输过程中要不停的转动，以防混凝土离析，混凝土搅拌运输车到达工地和卸料之前。应先使拌筒全速以14—18转/分转动1—2分钟，然后再进行反转卸料，反转之前，应使搅拌筒停稳不转。液压系统压力应符合使用说明书中的规定。不得随意调整，液压油的油质和油量应符合原定要求。环境温度高于+25摄氏度，从装料、运输、到卸料延续时间不得超过60分钟。环境温度低于+25摄氏度，上述时间不得超过90分钟。冬期施工时，应切实做到：开机前检查是否结冰，下班时认真排除拌筒内及供水系统内残存积水。关闭水泵开关，将控制手柄置于“停止”位置。在施工现场卸料完毕后。

The wheeled mobile concrete mixer has strong power. Before loading, the residual water and sundries in the mixing drum shall be drained. It shall be rotated continuously during transportation to prevent concrete segregation. Before the concrete mixer truck arrives at the construction site and discharges the materials. The mixing drum shall be rotated at full speed at 14-18 rpm for 1-2 minutes, and then reversed unloading shall be carried out. Before reversing, the mixing drum shall be stopped stably. The pressure of the hydraulic system shall comply with the provisions in the operating instructions. The oil quality and quantity of hydraulic oil shall meet the original requirements. When the ambient temperature is higher than + 25 ℃, the duration from loading, transportation and unloading shall not exceed 60 minutes. If the ambient temperature is lower than + 25 ℃, the above time shall not exceed 90 minutes. During winter construction, it is necessary to check whether there is ice before starting the machine, and carefully remove the residual water in the mixing drum and the water supply system after work. Turn off the water pump switch and set the control handle to the "stop" position. After unloading at the construction site.

目前国内混凝土施工中主流还是采取塌落度较大的，常见的采用滚筒搅拌机或者卧式搅拌站设备，然而对于干硬性混凝土搅拌应用较少，常规的滚筒式是通过筒壁的转动带动混凝土搅拌，对于含水量较低的砼无法胜任，平口搅拌机则是通过立轴带动圆盘中间的搅拌杆进行转动，混凝土可搅拌的较为充分。

At present, the mainstream of domestic concrete construction still adopts the equipment with large slump, and the drum mixer or horizontal mixing station is commonly used. However, the dry and hard concrete mixing is rarely used. The conventional drum type drives the concrete mixing through the rotation of the cylinder wall, which is not competent for the concrete with low water content. The flat mouth mixer drives the mixing rod in the middle of the disk through the vertical shaft to rotate, The concrete can be mixed sufficiently.

自走式混凝土搅拌机，它是一款集搅拌和运输为一体的多功能搅拌机，从而将搅拌、运输、装卸集于一身，可搅拌截止类型较为丰富，除了混凝土还可以搅拌饲料、粘稠性物质，干硬性混凝土，工程中的各项任务都可以自身之力独自完成。

The self-propelled concrete mixer is a multi-functional mixer integrating mixing and transportation, which integrates mixing, transportation and loading and unloading. There are many types of mixing cutoff. Besides concrete, it can also mix feed, viscous substances and dry hard concrete. All tasks in the project can be completed by itself.

平口朝天锅混凝土搅拌车装料前，应先排净拌筒内残存的积水和杂物，在运输过程中要不停的转动，以防混凝土离析，混凝土搅拌运输车到达工地和卸料之前。应先使拌筒全速以14—18转/分转动1—2分钟，然后再进行反转卸料，反转之前，应使搅拌筒停稳不转。液压系统压力应符合使用说明书中的规定。不得随意调整，液压油的油质和油量应符合原定要求。环境温度高于+25摄氏度，从装料、运输、到卸料延续时间不得超过60分钟。环境温度低于+25摄氏度，上述时间不得超过90分钟。冬期施工时，应切实做到：开机前检查是否结冰，下班时认真排除拌筒内及供水系统内残存积水。关闭水泵开关，将控制手柄置于“停止”位置。在施工现场卸料完毕后。

Before loading the concrete mixer truck with flat mouth facing to the sky, the remaining water and sundries in the mixing drum shall be drained first, and it shall be rotated continuously during transportation to prevent concrete segregation. Before the concrete mixer truck arrives at the construction site and discharges the materials. The mixing drum shall be rotated at full speed at 14-18 rpm for 1-2 minutes, and then reversed unloading shall be carried out. Before reversing, the mixing drum shall be stopped stably. The pressure of the hydraulic system shall comply with the provisions in the operating instructions. The oil quality and quantity of hydraulic oil shall meet the original requirements. When the ambient temperature is higher than + 25 ℃, the duration from loading, transportation and unloading shall not exceed 60 minutes. If the ambient temperature is lower than + 25 ℃, the above time shall not exceed 90 minutes. During winter construction, it is necessary to check whether there is ice before starting the machine, and carefully remove the residual water in the mixing drum and the water supply system after work. Turn off the water pump switch and set the control handle to the "stop" position. After unloading at the construction site.

自上料平口搅拌车是一款集合自动上料、搅拌、卸料、注水为一体的多功能搅拌车，这款平口搅拌车体积较小，灵活的比较高，并且省时间，效率高，投入成本较低。我们生产的自上料平口搅拌车不但能搅拌混凝土，还能搅拌可搅拌塑性、干硬性、流动性混凝土及轻骨料和砂浆，这款自上料平口搅拌车，主要适合空间比较小，路窄，大型搅拌车不容易进入的场合，比如在农村中小工程建设。它不仅是一台装载机，也还是一台罐车，同时还是一台搅拌车。我们的自上料平口搅拌车采用液压电子秤，能自动上料上水，并且能准确配比水泥混凝土我们的车还有液压装置，结构采用一体设计，在降低劳动力的同时，还可一次性完成上料，搅拌，运输等多项操作过程，使用范围也非常广泛。

The self feeding flat mouth mixer truck is a multi-functional mixer truck integrating automatic feeding, mixing, unloading and water injection. This flat mouth mixer truck is small in size, flexible, time-saving, high in efficiency and low in investment cost. The self feeding flat mouth mixer produced by us can not only mix concrete, but also mix plastic, dry and hard concrete, fluidity concrete, light aggregate and mortar. This self feeding flat mouth mixer is mainly suitable for occasions where the space is small, the road is narrow, and the large mixer is not easy to enter, such as the construction of small and medium-sized projects in rural areas. It is not only a loader, but also a tanker and a mixer. Our self feeding flat mouth mixer truck adopts hydraulic electronic scale, which can automatically feed and water, and can accurately mix cement concrete. Our truck also has hydraulic device, which is designed in one piece. While reducing labor force, it can also complete many operation processes such as feeding, mixing and transportation at one time, and has a very wide range of applications.

以上就是为大家介绍的有关自动混凝土搅拌机的详细的介绍,希望对您有所帮助.如果您有什么疑问的话,欢迎联系我们.我们将以的态度,为您提供服务http://www.sqjituan.cn

The above is the detailed introduction of the automatic concrete mixer for you. I hope it will help you. If you have any questions, please contact us. We will provide you with services with a professional attitude http://www.sqjituan.cn

上一页：混凝土搅拌车施工行车的注意事项下一页：控制好水泥自上料搅拌机设备用水量的方法

热门产品 / HOT PRODUCT